行業資訊
粉料撒布車打料注意事項你都知道嗎？
來源：http://www.bvzokj.cn/ 日期：2020-08-28
車輛打料時注意事項
Matters needing attention during vehicle feeding
粉料撒布車不同型號的車輛容積是不一樣的，因此打料的時候要特別注意車輛的容積，以免過于打料造成車廂撐鼓變形，甚至于開裂。
The vehicle volume of different models of powder spreader is different, so pay special attention to the volume of the vehicle when feeding, so as to avoid deformation and even cracking of the carriage drum caused by excessive feeding.
在施工過程中，有師傅可能會問，為什么我的車還沒裝到相對應的噸數車廂會變形呢？其實這個道理很簡單，這個和施工所用的物料比重有很大的關系。在一定的容積內，物料比重大了，裝載的物料噸位就多，物料比重小了裝載的物料噸位就少。那么如何更好的去注意呢？水泥撒布車租賃推薦了以下幾個小常識大家可以借鑒一下
During the construction process, a master may ask why my car has not been loaded to the corresponding tonnage, and the carriage will deform? In fact, this principle is very simple, which has a great relationship with the proportion of materials used in construction. In a certain volume, if the proportion of materials is large, the tonnage of materials loaded will be more, and if the proportion of materials is small, the tonnage of materials loaded will be less. So how to better pay attention to it? Cement spreader rental recommended the following a few common sense, we can learn from it
（1）、打料時注意好罐車的打料管方向，盡量保持罐車打料管和撒布車打料口在同一位置，避免彎折。
(1) During feeding, pay attention to the direction of the feeding pipe of the tanker, and try to keep the feeding pipe of the tanker and the feeding mouth of the spreader in the same position as far as possible, so as to avoid bending.
（2）、撒布操作系統頁面有材料密度設定，可根據材料密度（出廠設定為110×10kg/m?）設定去改變稱重報警提醒，材料密度設定數值越大，說明物料比重越大，稱重報警數值會越大；材料密度設定數值越小，說明物料比重越輕，稱重報警數值會越小。
(2) There is material density setting on the page of the spreading operation system. The weighing alarm can be changed according to the setting of material density (factory setting is 110 × 10kg / M?). The larger the material density is, the larger the weight alarm value will be; the smaller the material density setting value, the lighter the material specific gravity, the smaller the weighing alarm value.
（3）、同樣的罐車不同的物料也有裝的多與少的情況，有些罐車師傅也會知道材料密度是多少。比如，同樣的運輸罐車平時裝料35噸就滿了，當天裝了30噸，這種情況就說明該物料比重偏輕，打料施工的時候就必須得特別留意。
(3) In the same tank car, different materials are loaded with more or less. Some tank truck masters will also know how much the material density is. For example, the same transport tanker is usually filled with 35 tons of material, and 30 tons of material is loaded on the same day. This situation shows that the proportion of the material is relatively light, and special attention must be paid to the construction.
（4）、水泥的比重多受原材料比重影響較大；白灰的比重多受干濕度、摻雜的石粉、顆粒料的含量影響較大，白灰施工的時候要特別留意車輛的打料量。
(4) The specific gravity of cement is mainly affected by the specific gravity of raw materials; the specific gravity of lime is mainly affected by the dry humidity, the content of mixed stone powder and granular material. Special attention should be paid to the mixing amount of vehicles during lime construction.
（5）、有時可能存在罐車拉來的物料兩車多才能裝下的情況，有的師傅怕麻煩會選擇兩車打完，長時間如此也會對車輛及除塵系統造成損傷。
(5) Sometimes, there may be more than two trucks of materials pulled by the tank car to be loaded. Some masters will choose two trucks to finish the operation for fear of trouble. If this happens for a long time, the vehicle and dust removal system will be damaged.
以上還是關于水泥撒布車車輛打料時的注意事項，相信大家都有所了解了，如您還有其他疑問歡迎咨詢我們網站。
The above is about the cement spreader vehicle material when the matter, I believe you all understand, if you have other questions, welcome to consult our website.
公司地址：濟南市槐蔭區經一路273號群盛華城2號樓1-404
公司名稱：山東途暢路橋工程有限公司 
備案號：